The complete automotive resource for buyers, sellers, and owners like you.
Car, Truck and SUV Forums at Roadfly
+ Bentley Forums
+ BMW Forums
+ Cadillac Forums
+ Chevrolet Forums
+ Ferrari Forums
+ Jaguar Forums
+ Lamborghini Forums
+ Lotus Forums
+ Mercedes-Benz Forums
+ Maserati Forums
+ MINI Forums
+ Porsche Forums
+ General Discussion
+ Marketplace Forums
Re: E28 535is hit from side, steering off (archive)
[ Follow Ups ] [ 5-series (E28) Message Board ] [ Msg. Board FAQ ]
Posted by a on November 18, 2000 at 18:55:18:

In Reply to: Re: E28 535is hit from side, steering off posted by funfer on November 18, 2000 at 16:15:13:


Have you inspected your ball joints for play? Additionally, Your steering gear box may need to be adjusted...tightened up a bit.


At some point in the life of my 1987 535is it was hit in the front side panel that seriously enough to require the fender to be replaced. The car has a difficult time remaining in a straight line at various speeds as if the car wants to go another way other than where I am steering the car. The car has 16" rims off of a new 540 and is running with brand new Yokohama A520's not to mention brand new control arms. Before the new tires and control arms, the car would veer on it's own much worse than with these additions. It is hard to gather confindence while driving the car fast because I'm always waiting for the car to start moving in a different direction (slightly). To correct the cars direction I need to steer in the opposite direction. Normally, while on the freeway if you wanted to change to the lane just to the right you would tilt the wheel slightly to the right until you are satisfied with the turn and then back to center or 12:00. In my case I need to turn the wheel back to 10:00 and then back to center. You can imagine the instability created by all the wheel cranking. Long sloping turns take a lot of back and forth action in order to accomplish.

One of my first thoughts was that the cheap Dunlops on the car paired with worn control arms were the culprit. Replacing both of them helped quite a bit but the car is still wandering a bit. I especially notice this when I go to drive my 325is that has never been in an accident and the steering is perfect. Does anyone have any theories about what possibly else could be causing the car to wander. Keep in mind that after the control arms were replaced, there is still 2-3 inches of play in the steering wheel. The frame was checked and is perfectly straight and wheels and alignment show to be fine. Also, steering wheel is "permantly" point to the left about an inch which happens to be in the direction that you have to correction each time the car wanders right. This tells me that this has been a problem for a very long time but I don't know for sure. All input is greatly appreciated! Thanks!


i think the front end is stillout of alignment as evidenced by the off set of the steering wheel. who ever checked the alignment should have picked up on that. ball joints on the thrust arms should be checked for play. tie rod ends and the center link like wise. my 88 528e was getting increasingly sloppy steering. a 29.95 tierod set. put on the left side did wonders. i would definitely have all of this checked out be fore i fiddled with the steering box play. if any of the above linkage is replaced.the alignment should be checked. this is a dangerous condition and should be attended to.


Follow Ups:


[ Follow Ups ] [ 5-series (E28) Message Board ] [ Msg. Board FAQ ]
Questions, comments, or problems, please visit the Roadfly help desk.
Roadfly.com Logo © 1997 - 2008 Jump Internet Inc. All rights reserved.