Re: Loose Steering (archive)

I just had the dealer replace almost everything under the front end, suspension and steering-wise. $1,200 plus Bilsteins. Free 328 loaner. I wish I had the time to do it myself, but too much work to do.

My steering still has a bit of play, and I plan to try the things George mentions, like the steering box and 32 mm nut, but this is a busy time at the office so I haven't much time. Okay, its always busy. And I'm aggravated the dealer didn't check these things.

Anyway, the computerized 4 wheel alignment at the dealer was $89 less the 10% CCA discount. I'd sure recommend it. You're going to have a lot of time in it yourself. While its fun, its only fun the first time or two.

Good Luck.
Lin Gilbert

After months of fruitless checking for problems in the steering and front suspension, I finally decided to just ignore everything else and adjust the toe in myself. All of the front suspension parts are (now) new and the loose steering has persisted despite all other attempts to resolve the problem.

The good news, the steering is much better. I simply adjusted the tie rods by an equal amount on both sides, gradually increasing the toe-in. First adjustment, definite improvement but still a bit too loose. Second adjustment, almost back to the way I remember the steering 100,000 miles ago. Third adjustment, no, I don't think so as this would probably create adverse wear on the front tires. Although the car had been aligned, I don't think that the shop works on very many BMWs and perhaps their specifications are not that accurate.

The bad news, my steering wheel is now 90 degrees off. Maybe it is just time to take the car to the stealer and have him align the front end, set the steering box tension, and adjust the steering wheel. This, however, feels like admitting defeat since I have never had to take the car to the stealer in my four years/126,000 miles of ownership. Maybe it is just frustration since after I had packed everything up and was walking around the car, I could hear a distinct buzzing sound coming from the right rear. I looked underneath and, by pushing on the gas tank, I could temporarily stop the buzz. I am afraid that the fuel pump is starting to fail (it is the original pump). Oh well, something else to fix next weekend. (wouldn't it be nice to have just one weekend where you didn't have to fix something?)

Regards

Alex Lynch
1992 735i 189,000 miles (the money pit)
1972 2002 187,000 miles (a much shallower money pit)

Follow Ups:

Re: Loose Steering George Mann 08:00 10/04/2000 (3)
- Bilsteins Gilbert 21:45 10/05/2000 (0)
- Re: Loose Steering Robert 23:39 10/04/2000 (1)
  - Re: Loose Nut Steering Leo 750iL 21:17 10/07/2000 (0)

[ Follow Ups ] [ 7-series (E32) Message Board ] [ Msg. Board FAQ ]

Questions, comments, or problems, please visit the Roadfly help desk.